Thrust-to-weight ratio is a dimensionless ratio of thrust to weight of a rocket, jet engine, propeller engine, or a vehicle propelled by such an engine that is an indicator of the performance of the engine or vehicle.
The instantaneous thrust-to-weight ratio of a vehicle varies continually during operation due to progressive consumption of fuel or propellant and in some cases a gravity gradient. The thrust-to-weight ratio based on initial thrust and weight is often published and used as a figure of merit for quantitative comparison of a vehicle's initial performance.
Calculation
[edit]The thrust-to-weight ratio is calculated by dividing the thrust (in SI units – in newtons) by the weight (in newtons) of the engine or vehicle. The weight (N) is calculated by multiplying the mass in kilograms (kg) by the acceleration due to gravity (m/s2). The thrust can also be measured in pound-force (lbf), provided the weight is measured in pounds (lb). Division using these two values still gives the numerically correct (dimensionless) thrust-to-weight ratio. For valid comparison of the initial thrust-to-weight ratio of two or more engines or vehicles, thrust must be measured under controlled conditions.
Because an aircraft's weight can vary considerably, depending on factors such as munition load, fuel load, cargo weight, or even the weight of the pilot, the thrust-to-weight ratio is also variable and even changes during flight operations. There are several standards for determining the weight of an aircraft used to calculate the thrust-to-weight ratio range.
- Empty weight - The weight of the aircraft minus fuel, munitions, cargo, and crew.
- Combat weight - Primarily for determining the performance capabilities of fighter aircraft, it is the weight of the aircraft with full munitions and missiles, half fuel, and no drop tanks or bombs.
- Max takeoff weight - The weight of the aircraft when fully loaded with the maximum fuel and cargo that it can safely takeoff with.[1]
Aircraft
[edit]The thrust-to-weight ratio and lift-to-drag ratio are the two most important parameters in determining the performance of an aircraft.
The thrust-to-weight ratio varies continually during a flight. Thrust varies with throttle setting, airspeed, altitude, air temperature, etc. Weight varies with fuel burn and payload changes. For aircraft, the quoted thrust-to-weight ratio is often the maximum static thrust at sea level divided by the maximum takeoff weight.[2] Aircraft with thrust-to-weight ratio greater than 1:1 can pitch straight up and maintain airspeed until performance decreases at higher altitude.[3]
A plane can take off even if the thrust is less than its weight as, unlike a rocket, the lifting force is produced by lift from the wings, not directly by thrust from the engine. As long as the aircraft can produce enough thrust to travel at a horizontal speed above its stall speed, the wings will produce enough lift to counter the weight of the aircraft.
Propeller-driven aircraft
[edit]For propeller-driven aircraft, the thrust-to-weight ratio can be calculated as follows in imperial units:[4]
where is propulsive efficiency (typically 0.65 for wooden propellers, 0.75 metal fixed pitch and up to 0.85 for constant-speed propellers), hp is the engine's shaft horsepower, and is true airspeed in feet per second, weight is in lbs.
The metric formula is:
Rockets
[edit]![](https://upload.wikimedia.org/wikipedia/commons/thumb/8/8b/Thrust_to_weight_ratio_vs_Isp.png/350px-Thrust_to_weight_ratio_vs_Isp.png)
The thrust-to-weight ratio of a rocket, or rocket-propelled vehicle, is an indicator of its acceleration expressed in multiples of gravitational acceleration g.[5]
Rockets and rocket-propelled vehicles operate in a wide range of gravitational environments, including the weightless environment. The thrust-to-weight ratio is usually calculated from initial gross weight at sea level on earth[6] and is sometimes called thrust-to-Earth-weight ratio.[7] The thrust-to-Earth-weight ratio of a rocket or rocket-propelled vehicle is an indicator of its acceleration expressed in multiples of earth's gravitational acceleration, g0.[5]
The thrust-to-weight ratio of a rocket improves as the propellant is burned. With constant thrust, the maximum ratio (maximum acceleration of the vehicle) is achieved just before the propellant is fully consumed. Each rocket has a characteristic thrust-to-weight curve, or acceleration curve, not just a scalar quantity.
The thrust-to-weight ratio of an engine is greater than that of the complete launch vehicle, but is nonetheless useful because it determines the maximum acceleration that any vehicle using that engine could theoretically achieve with minimum propellant and structure attached.
For a takeoff from the surface of the earth using thrust and no aerodynamic lift, the thrust-to-weight ratio for the whole vehicle must be greater than one. In general, the thrust-to-weight ratio is numerically equal to the g-force that the vehicle can generate.[5] Take-off can occur when the vehicle's g-force exceeds local gravity (expressed as a multiple of g0).
The thrust-to-weight ratio of rockets typically greatly exceeds that of airbreathing jet engines because the comparatively far greater density of rocket fuel eliminates the need for much engineering materials to pressurize it.
Many factors affect thrust-to-weight ratio. The instantaneous value typically varies over the duration of flight with the variations in thrust due to speed and altitude, together with changes in weight due to the amount of remaining propellant, and payload mass. Factors with the greatest effect include freestream air temperature, pressure, density, and composition. Depending on the engine or vehicle under consideration, the actual performance will often be affected by buoyancy and local gravitational field strength.
Examples
[edit]Aircraft
[edit]Vehicle | thrust-weight ratio | Notes |
---|---|---|
Northrop Grumman B-2 Spirit | 0.205[8] | Max take-off weight, full power |
Airbus A340 | 0.2229 | Max take-off weight, full power (A340-300 Enhanced) |
Airbus A380 | 0.227 | Max take-off weight, full power |
Boeing 747-8 | 0.269 | Max take-off weight, full power |
Boeing 777 | 0.285 | Max take-off weight, full power (777-200ER) |
Boeing 737 MAX 8 | 0.311 | Max take-off weight, full power |
Airbus A320neo | 0.310 | Max take-off weight, full power |
Boeing 757-200 | 0.341 | Max take-off weight, full power (w/Rolls-Royce RB211) |
Tupolev 154B | 0.360 | Max take-off weight, full power (w/Kuznecov NK-82) |
Tupolev Tu-160 | 0.363 [citation needed] | Max take-off weight, full afterburners |
Concorde | 0.372 | Max take-off weight, full afterburners |
Rockwell International B-1 Lancer | 0.38 | Max take-off weight, full afterburners |
HESA Kowsar | 0.61 | With full fuel, afterburners. |
BAE Hawk | 0.65[9] | |
Lockheed Martin F-35 A | 0.87 [citation needed] | With full fuel (1.07 with 50% fuel, 1.19 with 25% fuel) |
HAL Tejas Mk 1 | 1.07 | With full fuel |
CAC/PAC JF-17 Thunder | 1.07 | With full fuel |
Dassault Rafale | 0.988[10] | Version M, 100% fuel, 2 EM A2A missile, 2 IR A2A missiles |
Sukhoi Su-30MKM | 1.00[11] | Loaded weight with 56% internal fuel |
McDonnell Douglas F-15 | 1.04[12] | Nominally loaded |
Mikoyan MiG-29 | 1.09[13] | Full internal fuel, 4 AAMs |
Lockheed Martin F-22 | >1.09 (1.26 with loaded weight and 50% fuel)[14] | |
General Dynamics F-16 | 1.096[citation needed] (1.24 with loaded weight & 50% fuel) | |
Hawker Siddeley Harrier | 1.1[citation needed] | VTOL |
Eurofighter Typhoon | 1.15[15] | Interceptor configuration |
Sukhoi Su-35 | 1.30 | |
Space Shuttle | 1.5[citation needed] | Take-off |
Simorgh (rocket) | 1.83 | |
Space Shuttle | 3 | Peak |
Jet and rocket engines
[edit]Engine | Mass | Thrust, vacuum | Thrust-to- weight ratio | |
---|---|---|---|---|
(kN) | (lbf) | |||
RD-0410 nuclear rocket engine[16][17] | 2,000 kg (4,400 lb) | 35.2 | 7,900 | 1.8 |
Pratt & Whitney J58 jet engine (Lockheed SR-71 Blackbird)[18][19] |
2,722 kg (6,001 lb) | 150 | 34,000 | 5.6 |
Rolls-Royce/Snecma Olympus 593 turbojet with reheat (Concorde)[20] |
3,175 kg (7,000 lb) | 169.2 | 38,000 | 5.4 |
Pratt & Whitney F119[21] | 1,800 kg (4,000 lb) | 91 | 20,500 | 7.95 |
PBS TJ40-G1NS jet engine[22] | 3.6 kg (7.9 lb) | 0.425 | 96 | 12 |
RD-0750 rocket engine three-propellant mode[23] |
4,621 kg (10,188 lb) | 1,413 | 318,000 | 31.2 |
RD-0146 rocket engine[24] | 260 kg (570 lb) | 98 | 22,000 | 38.4 |
Rocketdyne RS-25 rocket engine (Space Shuttle Main Engine)[25] |
3,177 kg (7,004 lb) | 2,278 | 512,000 | 73.1 |
RD-180 rocket engine[26] | 5,393 kg (11,890 lb) | 4,152 | 78.7 | |
RD-170 rocket engine | 9,750 kg (21,500 lb) | 7,887 | 1,773,000 | 82.5 |
F-1 (Saturn V first stage)[27] |
8,391 kg (18,499 lb) | 7,740.5 | 1,740,100 | 94.1 |
NK-33 rocket engine[28] | 1,222 kg (2,694 lb) | 1,638 | 368,000 | 136.7 |
SpaceX Raptor 2 rocket engine[29] | 1,600 kg (3,500 lb) | 2,256 | 507,000 | 143.8 |
Merlin 1D rocket engine, full-thrust version[30][31] |
467 kg (1,030 lb) | 914 | 205,500 | 199.5 |
Fighter aircraft
[edit]Specifications | F-15K[a] | F-15C | MiG-29K | MiG-29B | JF-17 | J-10 | F-35A | F-35B | F-35C | F-22 | LCA Mk-1 |
---|---|---|---|---|---|---|---|---|---|---|---|
Engines thrust, maximum (N) | 259,420 (2) | 208,622 (2) | 176,514 (2) | 162,805 (2) | 84,400 (1) | 122,580 (1) | 177,484 (1) | 177,484 (1) | 177,484 (1) | 311,376 (2) | 84,516 (1) |
Aircraft mass, empty (kg) | 17,010 | 14,379 | 12,723 | 10,900 | 7,965 | 09,250 | 13,290 | 14,515 | 15,785 | 19,673 | 6,560 |
Aircraft mass, full fuel (kg) | 23,143 | 20,671 | 17,963 | 14,405 | 11,365 | 13,044 | 21,672 | 20,867 | 24,403 | 27,836 | 9,500 |
Aircraft mass, max. take-off load (kg) | 36,741 | 30,845 | 22,400 | 18,500 | 13,500 | 19,277 | 31,752 | 27,216 | 31,752 | 37,869 | 13,500 |
Total fuel mass (kg) | 06,133 | 06,292 | 05,240 | 03,505 | 02,300 | 03,794 | 08,382 | 06,352 | 08,618 | 08,163 | 02,458 |
T/W ratio, full fuel | 1.14 | 1.03 | 1.00 | 1.15 | 1.07 | 1.05 | 0.84 | 0.87 | 0.74 | 1.14 | 1.07 |
T/W ratio, max. take-off load | 0.72 | 0.69 | 0.80 | 0.89 | 0.70 | 0.80 | 0.57 | 0.67 | 0.57 | 0.84 | 0.80 |
- Table for Jet and rocket engines: jet thrust is at sea level
- Fuel density used in calculations: 0.803 kg/l
- For the metric table, the T/W ratio is calculated by dividing the thrust by the product of the full fuel aircraft weight and the acceleration of gravity.
- J-10's engine rating is of AL-31FN.
See also
[edit]Notes
[edit]- ^ Pratt & Whitney engines
- ^ NASA Technical Memorandum 86352 - Some Fighter Aircraft Trends
- ^ John P. Fielding, Introduction to Aircraft Design, Section 3.1 (p.21)
- ^ Nickell, Paul; Rogoway, Tyler (2016-05-09). "What it's Like to Fly the F-16N Viper, Topgun's Legendary Hotrod". The Drive. Archived from the original on 2019-10-31. Retrieved 2019-10-31.
- ^ Daniel P. Raymer, Aircraft Design: A Conceptual Approach, Equations 3.9 and 5.1
- ^ a b c George P. Sutton & Oscar Biblarz, Rocket Propulsion Elements (p. 442, 7th edition) "thrust-to-weight ratio F/Wg is a dimensionless parameter that is identical to the acceleration of the rocket propulsion system (expressed in multiples of g0) if it could fly by itself in a gravity-free vacuum"
- ^ George P. Sutton & Oscar Biblarz, Rocket Propulsion Elements (p. 442, 7th edition) "The loaded weight Wg is the sea-level initial gross weight of propellant and rocket propulsion system hardware."
- ^ "Thrust-to-Earth-weight ratio". The Internet Encyclopedia of Science. Archived from the original on 2008-03-20. Retrieved 2009-02-22.
- ^ Northrop Grumman B-2 Spirit
- ^ BAE Systems Hawk
- ^ "AviationsMilitaires.net — Dassault Rafale C". www.aviationsmilitaires.net. Archived from the original on 25 February 2014. Retrieved 30 April 2018.
- ^ Sukhoi Su-30MKM#Specifications .28Su-30MKM.29
- ^ "F-15 Eagle Aircraft". About.com:Inventors. Archived from the original on July 9, 2012. Retrieved 2009-03-03.
- ^ Pike, John. "MiG-29 FULCRUM". www.globalsecurity.org. Archived from the original on 19 August 2017. Retrieved 30 April 2018.
- ^ "AviationsMilitaires.net — Lockheed-Martin F-22 Raptor". www.aviationsmilitaires.net. Archived from the original on 25 February 2014. Retrieved 30 April 2018.
- ^ "Eurofighter Typhoon". eurofighter.airpower.at. Archived from the original on 9 November 2016. Retrieved 30 April 2018.
- ^ Wade, Mark. "RD-0410". Encyclopedia Astronautica. Retrieved 2009-09-25.
- ^ РД0410. Ядерный ракетный двигатель. Перспективные космические аппараты [RD0410. Nuclear Rocket Engine. Advanced launch vehicles] (in Russian). KBKhA - Chemical Automatics Design Bureau. Archived from the original on 30 November 2010.
- ^ "Aircraft: Lockheed SR-71A Blackbird". Archived from the original on 2012-07-29. Retrieved 2010-04-16.
- ^ "Factsheets : Pratt & Whitney J58 Turbojet". National Museum of the United States Air Force. Archived from the original on 2015-04-04. Retrieved 2010-04-15.
- ^ "Rolls-Royce SNECMA Olympus - Jane's Transport News". Archived from the original on 2010-08-06. Retrieved 2009-09-25.
With afterburner, reverser and nozzle ... 3,175 kg ... Afterburner ... 169.2 kN
- ^ Military Jet Engine Acquisition, RAND, 2002.
- ^ "PBS TJ40-G1NS". PBS Velká Bíteš. Retrieved 20 July 2024.
- ^ "Конструкторское бюро химавтоматики" - Научно-исследовательский комплекс / РД0750. [«Konstruktorskoe Buro Khimavtomatiky» - Scientific-Research Complex / RD0750.]. KBKhA - Chemical Automatics Design Bureau. Archived from the original on 26 July 2011.
- ^ Wade, Mark. "RD-0146". Encyclopedia Astronautica. Retrieved 2009-09-25.
- ^ SSME
- ^ "RD-180". Retrieved 2009-09-25.
- ^ Encyclopedia Astronautica: F-1
- ^ Wade, Mark. "NK-33". Encyclopedia Astronautica. Retrieved 2022-08-24.
- ^ Sesnic, Trevor (2022-07-14). "Raptor 1 vs Raptor 2: What did SpaceX change?". Everyday Astronaut. Retrieved 2022-11-07.
- ^ Mueller, Thomas (June 8, 2015). "Is SpaceX's Merlin 1D's thrust-to-weight ratio of 150+ believable?". Quora. Retrieved July 9, 2015.
The Merlin 1D weighs 1030 pounds, including the hydraulic steering (TVC) actuators. It makes 162,500 pounds of thrust in vacuum. that is nearly 158 thrust/weight. The new full thrust variant weighs the same and makes about 185,500 lbs force in vacuum.
- ^ "SpaceX". SpaceX. Retrieved 2022-11-07.
References
[edit]- John P. Fielding. Introduction to Aircraft Design, Cambridge University Press, ISBN 978-0-521-65722-8
- Daniel P. Raymer (1989). Aircraft Design: A Conceptual Approach, American Institute of Aeronautics and Astronautics, Inc., Washington, DC. ISBN 0-930403-51-7
- George P. Sutton & Oscar Biblarz. Rocket Propulsion Elements, Wiley, ISBN 978-0-471-32642-7